View non-flash version
WWW.MARINELINK.COM 21This summer the MTS Duandra was launched in Benelux as the world?s Þ rst semi-hybrid inland waterway tanker built by Shipyard Trico B.V. The ship uses Volvo Penta diesel engines for both propulsion and generator set that helps to reduce emissions signiÞ cantly. The two standard Volvo Penta D16 MG Gensets on MTS Duandra generate power for on-board electricity, thruster, cargo pumps and two electric engines which are part of the propulsion system. This setup re- duces the total installed diesel power on-board the Duandra with approximately 30% compared to a conventionally built ship. The savings made were used to in- vest in the extra electric equipment and as well to invest in catalytic converter and particulate Þ lter on all the D16 en- gines on-board. By using this technique the NOx emissions are reduced by ap-proximately 70 to 90% and particulates are reduced by about 40%. The propulsion system consists of a 750 hp Volvo Penta propulsion engine connected to a MMW1700 gearbox. On the gearbox a 475 hp electric motor is also connected and together they can drive the 1,225 hp designed propeller to full speed on request. The propeller can be diesel-electric, diesel direct or com-bined driven, so the skipper can always Þ nd the most ef Þ cient way of propul- sion and has a lot of redundancy which guarantees an almost 100% uptime of this ship. Through this semi-hybrid, the propulsion and Gensets engines run on controllable higher load compared to a standard propulsion installation, which is in favor of the speciÞ c fuel consump- tion of the propulsion engines compared to a standard single propulsion engine unit of 1225hp. This semi hybrid concept proves that it is possible to build a ship with future emission levels, for a con-ventional built ship?s price on existing emission levels and that?s the Þ rst time ever done. The whole scope of supply, the propulsion engines, and Gensets and after treatment equipment is delivered through the Volvo Penta Marine Com- mercial Center Terlouw in Rotterdam. They will also take care of the full ser- vice of all equipment which is a big ad-vantage for the owner of the ship.www.volvopenta.com 90% Less NOxFor a New Inland Waterway Tanker MR #1 (18-25).indd 21MR #1 (18-25).indd 211/4/2013 9:06:48 AM1/4/2013 9:06:48 AM
